[Date Prev][Date Next][Thread Prev][Thread Next][Date Index][Thread Index] [New Search]
Yes, it's a 69. I am skeptical also regarding replacement of the trunk seal; however, it is leaking, the trunk also is getting wet. So, replacement is on the menu anyhow. I still think the leak is probably coming from another source, but playing detective I'll eliminate the things I know are possible problems first. No, I wasn't referring to the cable release for the gas flap; there's a wire, not cable, running through the passenger-side fender. I appreciate your feedback, sorry for the double messages Jim. Joe -----Original Message----- From: Jim Adney [mailto:jadney@vwtype3.org] Sent: Friday, March 21, 2003 9:41 AM To: type3@vwtype3.org Subject: RE: [T3] Water leaks, minor victory On 21 Mar 2003 at 6:41, Vlach, Joe -CKHS wrote: > I got another chance to do investigating regarding why my socks are wet. I used > a hose and placed it around various spots (fresh air intake, windshield seal, > etc.) One thing I found interesting is that the water, believe it or not, > appeared to accumulate behind the trunk seal then seep through were the seal has > deteriorated wick down the hinge and find its way through the firewall into the > cab and eventually onto the floor. It sounds like a long shot, but I am going > to replace the trunk seal. I haven't seen or heard of that route, but that doesn't mean it's not possible. This is a 69, right? I'm skeptical, though. > While I was playing water boy, I ran the hose full flow through the fresh > air boxes...no leaks. I did find that the windshield wiper motor had water > dripping from above. It's hard to tell, but I think the wiper fluid spray > nozzle is allowing in a bit of water. .Could be, but this would usually be minor. > What did seem to help was to silicone the two holes in both sides of the > fenders (antenna wire hole on driver's side, I don't know what the other > wire is on the passenger side. The antenna wire hole is a BIG problem if there is no grommet there, and it is much too common for the radio installer to have saved himself 30 seconds by leaving out that grommet. This will only leak while driving, but it will leak a LOT if you drive on really wet pavement, as wheel spray will really pump the water up there. The cable on the other side is the fuel flap release cable. That should have its own seal from the factory. The fact that you didn't know what it was, means that it is probably broken and you don't use it. So it may actually be cut off on both ends meaning that it can leak thru the middle. I suggest that you remove the 2 screws, take all the remaining parts out, and either fix them if possible, or cut them off cleanly and seal the center hole (weld, braze, solder, or silicone) and reinstall just the sealed plate with its OE gasket and screws. BTW, there's no reason to send your messages both to me and the list. I don't need 2 copies. ;-) -- Jim Adney jadney@vwtype3.org Madison, WI 53711-3054 USA ------------------------------------------------------------------- List info at http://www.vwtype3.org/list | mailto:gregm@vwtype3.org